Founding Research Journal

Founding Research Journal

The Effect of Withdrawal Rate on the Microstructure of Ni-based Superalloy GTD-111 through the Directional Solidification

Document Type : Original Research Article

Authors
1 M.Sc., Materials Science and Engineering, Sharif University of Technology, Tehran, Iran.‎
2 Ph.D. Student,, Materials and Energy Research Center, Tehran, Iran. ‎
3 Associate Professor, Materials Science and Engineering Department, Sharif University of Technology, Tehran, Iran. ‎
10.22034/frj.2021.278477.1134
Abstract
Effects of withdrawal rate on the structure of directionally solidified GTD-111 Ni-based superalloy were investigated. To this end, DS specimens were first obtained by the Bridgman Furnace (equipped with a graphite cooling zone) at withdrawal rate of 1 and 10 mm/min. Then, structural investigation was carried out by optical microscopy and field emission scanning electron microscopy at longitudinal and transverse sections with respect to solidification direction at the bottom (location of starting solidification) and top (location of finishing solidification) zone of specimens. The results showed that the polycrystalline grain zone at bottom of the specimen enlarged with increasing the withdrawal rate. Furthermore, with increasing withdrawal rate from R=1mm/min to R=10mm/min, the primary and secondary arm spacing decreased from 445μm to 252μm and from 110μm to 60μm, respectively. The γʹ size also decreased from 468μm to 421μm at top of specimens and from 711μm to 604μm at bottom of specimens with increasing the withdrawal rate from R=1mm/min to R=10mm/min. In addition, due to the direction of heat transfer during directional solidification at a constant withdrawal rate, the bottom zone of specimen was exposed to heat output from top zone. This led to increase the γʹ size at bottom zone (711μm at R=1mm/min and 604μm at R=10mm/min) compared to the top zone (468μm at R=1mm/min and 421μm at R=10mm/min) of specimen. The best microstructure belonged to the top zone of DS specimen with withdrawal rate of 10mm/min which has a small gamma-prime average size, homogenous distribution, and regular morphology.
Keywords
Subjects

‎[1]‎ Sajjadi S.A. , Zebarjad S.M. , Guthrie R.I.L. , ‎Isac, M., Microstructure evolution of high-‎‎performance Ni-base superalloy GTD-111 with ‎heat treatment parameters, Journal of ‎Materials ‎Processing Technology, 2006, 175, 376-‎‎381.‎
‎[2]‎ Szczotok A., Richter J., Cwajna J., ‎Stereological characterization of γ′ phase ‎precipitation in ‎CMSX-6 monocrystalline nickel-‎base superalloy, Materials Characterization, 2009, ‎‎60, 1114-‎‎1119.‎
‎[3]‎ Rahimian M., Milenkovic S., Sabirov I., ‎Microstructure and hardness evolution in MAR-‎M247 ‎Ni-based superalloy processed by controlled ‎cooling and double heat treatment, Journal of ‎Alloys ‎and Compounds, 2013, 550, 339-‎‎344.‎
‎[4]‎ Geddes B., Leon H., Huang X., Superalloys: ‎alloying and performance, ASM ‎International, ‎‎2010.‎
‎[5]‎ Zhang X., Zhou Y., Jin T., Sun X., Liu L., Effect ‎of solidification rate on grain structure ‎evolution ‎during directional solidification of a Ni-based ‎superalloy, Journal of Materials Science ‎& ‎Technology, 2013, 29, 879-883.‎
‎[6]‎ Flemings M.C., Solidification processing, Metallurgical Transactions, 1974, 5, 2121-2134.‎
‎[7]‎ Wang F. , Ma D. , Zhang J. , Liu L. , Hong J. , ‎Bogner S., Bührig-Polaczek A.,  Effect ‎of ‎solidification parameters on the microstructures of ‎superalloy CMSX-6 formed during the ‎downward ‎directional solidification process, Journal of ‎Crystal Growth, 2014, 389, 47-54.‎
‎[8]‎ Zhao X., Liu L., Yu Z., Zhang W., Zhang J., ‎Fu H., Influence of directional ‎solidification ‎variables on the microstructure and crystal ‎orientation of AM3 under high thermal ‎gradient, ‎Journal of Materials Science, 2010, 45, ‎‎6101-6107.‎
‎[9]‎  Xu C., Zhou L.Z., Guo J.T., Yang G.X., Effect ‎of withdrawal rate on microstructures ‎and ‎mechanical properties of directionally solidified ‎superalloy DZ445, The Chinese Journal ‎of ‎Nonferrous Metals, 2011, 21, 757.‎
‎[10] Dadkhah A., Kermanpur A., On the ‎precipitation hardening of the directionally ‎solidified ‎GTD-111 Ni-base superalloy: ‎Microstructures and mechanical properties, ‎Materials Science and ‎Engineering: A, 2017, 685, ‎‎79-86.‎
‎[11] Fallah P., Kebriyaei A., Varahram N., The ‎effect of precipitation hardening ‎on ‎microstructural characteristics of ‎directionally ‎solidified nickel-based superalloy GTD-111,‎ ‏Founding Research Journal, 2017, 1(2) 109-120.‎‏
‎[12] ‏Seifollahi M., Abbasi M., Tavakoli M., ‎Ghazi Mir Saeed, M., Effects of temperature ‎and ‎time of secondary solution heat treatment on γ' ‎phase distribution of GTD-111 ‎polycrystalline ‎superalloy, Metallurgical Engineering, 2019, 22, ‎‎42-51.‎
‎[13] ‎‏‏Schilke P.W., Foster A.D., Pepe J.L., Beltran ‎A.M., Advanced‎‏ ‏materials propel progress ‎in ‎land-based gas turbines, Advanced Materials & ‎Processes,  1992, 4, 22-30.‎
‎[14]‎ Gündüz M., Çadırl E., Directional ‎solidification of aluminium–copper alloys, ‎Materials ‎Science and Engineering: A, 2002, 327, 167-185. ‎
‎[15]‎ Spear R., Gardner G., Dendrite cell size, AFS ‎Transactions, 1963, 71, 209-215.‎
‎[16]‎ Schneider M.C., Gu J.P., Beckermann C., ‎Boettinger W.J., Kattner U.R., Modeling ‎of ‎micro-and macrosegregation and freckle ‎formation in single-crystal nickel-base ‎superalloy ‎directional solidification, Metallurgical and ‎Materials Transactions A, 1997, 28, ‎‎1517-‎‎1531.‎
‎[17]‎ Zhou Y., Sun X., Effect of solidification rate ‎on competitive grain growth in ‎directional ‎solidification of a nickel-base superalloy, Science ‎China Technological Sciences, 2012, 55, ‎‎1327-1334.‎
‎[18]‎ Walton D., Chalmers U.B., The origin of the ‎preferred orientation in the columnar zone ‎of ‎ingots, Transactions of the American Institute of ‎Mining, Metallurgical, and Petroleum ‎Engineers, ‎ 1959, 215, 447-457.‎
‎[19]‎ Zhou Y., Volek A., Green N., Mechanism of ‎competitive grain growth in ‎directional ‎solidification of a nickel-base superalloy, Acta ‎Materialia, 2008, 56, 2631-2637.‎
‎[20]‎ Milenkovic S., Rahimian M., Sabirov ‎I., Maestro L., Effect of solidification ‎parameters on ‎the secondary dendrite arm spacing ‎in MAR M-247 superalloy determined by a novel ‎approach, EUROSUPERALLOYS, 2nd European Symposium on Superalloys and their Applications, EDP ‎Sciences, 2014, 14, 13004.‎
‎[21]‎ Weiguo Z., Lin L., Taiwen H., Xinbao Z., et al, Influence of directional ‎solidification ‎variables on primary dendrite arm spacing of Ni-‎based superalloy DZ125, China Foundry, 2009, 6(4) 300-304.‎
‎[22]‎ Zhang Y., Huang B., Li J., Microstructural ‎evolution with a wide range of ‎solidification ‎cooling rates in a Ni-based superalloy, ‎Metallurgical and Materials Transactions A, 2013‎, ‎‎44, 164-1644.‎
‎[23]‎ Elliot A.J., Tin S., King W.T., Huang S.C., ‎Gigliotti M.F.X., and et al, Directional ‎solidification of ‎large superalloy castings with ‎radiation and liquid-metal cooling: A comparative ‎assessment, ‎Metallurgical and Materials ‎Transactions A, 2004, 35, 3221-3231.‎
‎[24]‎ Dadkhah A., Kermanpur A., On the ‎precipitation hardening of the directionally ‎solidified ‎GTD-111 Ni-base superalloy: ‎Microstructures and mechanical properties, ‎Materials Science and ‎Engineering: A, 2017, 685, 79-86.‎
‎[25]‎ Porter D.A., Easterling K.E., Phase ‎transformations in metals and alloys, 3d Ed., CRC ‎Press, ‎New York, 2009, 189-195.‎
‎[26]‎ Liu L.,  Huang T., Qu M., and ‎et al, High thermal gradient ‎directional ‎solidification and its application in the processing ‎of nickel-based superalloys, Journal of ‎Materials ‎Processing Technology, 2010, 210, 159-‎‎165.‎
‎[27]‎ Singh A.R.P., Nag S., Hwang J.Y., Viswanathan ‎G.B., Influence of cooling rate on the ‎development ‎of multiple generations of γ′ precipitates in a ‎commercial nickel base superalloy, ‎Materials ‎Characterization, 2011, 62, 878-886.‎
‎[28]‎ Masoumi F., Shahriari D., Jahazi M., Cormier J., ‎ Devaux A., Transient liquid phase ‎bonding of ‎aerospace single crystal Rene-N5 superalloy, ‎Scientific Reports, 2016, 6, 1-16.
Volume 4, Issue 4 - Serial Number 15
Winter 2021
Pages 237-246

  • Receive Date 26 March 2021
  • Revise Date 23 April 2021
  • Accept Date 29 April 2021